Desarrollo y capacidad de remoción de los pesticidas atrazina, clorpirifós y endosulfán por parte de cepas de Aspergillus sección Flavi no toxigénicas / Development and removal ability of non-toxigenic Aspergillus section Flavi in presence of atrazine, chlorpyrifos and endosulfan

This study evaluated the in vitro effect of three concentrations of atrazine, chlorpyrifos and endosulfan on the growth parameters of four non-toxigenic Aspergillus section Flavi strains. The ability of the strains to remove these pesticides in a synthetic medium was also determined. Growth parameters were measured on soil extract solid medium supplied with 5,10 and 20mg/l of each pesticide, and conditioned to -0.70, -2.78, -7.06 and -10.0 water potential (MPa). Removal assays were performed in Czapek Doc medium (CZD) supplied with 20mg/l of each pesticide under optimal environmental conditions (-2.78 of MPa and 25 °C). The residual levels of each pesticide were detected by the reversed-phase HPLC/fluorescence detection system. The lag phases of the strains significantly decreased in the presence of the pesticides with respect to the control media. This result indicates a fast adaptation to the conditions assayed. Similarly, the mycelial growth rates in the different treatments increased depending on pesticide concentrations. Aspergillus oryzae AM 1 and AM 2 strains showed high percentages of atrazine degradation (above 90%), followed by endosulfan (56 and 76%) and chlorpyrifos (50 and 73%) after 30 days of incubation. A significant (p <0.001) correlation (r = 0.974) between removal percentages and growth rate was found. This study shows that non-toxigenic Aspergillus section Flavi strains from agricultural soils are able to effectively grow in the presence of high concentrations of atrazine, chlorpyrifos and endosulfan under a wide range of MPa conditions. Moreover, these strains have the ability to remove high levels of these pesticides in vitro in a short time.

En este estudio se evaluó los efectos in vitro de 3 concentraciones de atrazina, clorpirifós y endosulfán sobre los parámetros de crecimiento de 4 cepas no toxigénicas de Aspergillus sección Flavi. También se evaluó la capacidad de las cepas de remover los pesticidas. Los parámetros de crecimiento se ensayaron en medio agar extracto de suelo suplementado con 5, 10 y 20mg/l de cada pesticida y acondicionado a -0.70, -2.78, -7.06 y -10.0 de potencial de agua (MPa). Los ensayos de remoción se realizaron en medio Czapek Dox con 20mg/l de cada pesticida bajo condiciones óptimas de crecimiento (-2.78 de MPa y 25 °C). Los niveles residuales de atrazina, clorpirifós y endosulfán se detectaron en un sistema HPLC con detección por fluorescencia. La fase de latencia de las cepas disminuyó significantemente en presencia de los pesticidas, indicando una rápida adaptación a dichas condiciones. La velocidad de crecimiento se incrementó considerablemente dependiendo de la concentración de pesticida. Las cepas Aspergillus oryzae AM1 y AM2 mostraron porcentajes elevados de degradación de atrazina (aproximadamente el 90%), seguidos por endosulfán (56 y 76%) y clorpirifós (50 y 73%). Se observó una correlación (r = 0.974) significante (p <0.001) entre el porcentaje de pesticida removido y la velocidad de crecimiento. Este estudio muestra que cepas no-toxigénicas de Aspergillus sección Flavi aisladas de suelos agrícolas desarrollan eficientemente en presencia de altas concentraciones de atrazina, clorpirifós y endosulfán en un amplio rango de MPa. Además, presentan capacidad de remover in vitro altos niveles de pesticidas en corto tiempo.

The hydrolysis of agro-industrial residues by holocellulose-degrading enzymes

Holocellulose structures from agro-industrial residues rely on main and side chain attacking enzymes with different specificities for complete hydrolysis. Combinations of crude enzymatic extracts from different fungal species, including Aspergillus terreus, Aspergillus oryzae, Aspergillus niger and Trichoderma longibrachiatum, were applied to sugar cane bagasse, banana stem and dirty cotton residue to investigate the hydrolysis of holocellulose structures. A. terreus and A. oryzae were the best producers of FPase and xylanase activities. A combination of A. terreus and A. oryzae extracts in a 50% proportion provided optimal hydrolysis of dirty cotton residue and banana stem. For the hydrolysis of sugar cane bagasse, the best results were obtained with samples only containing A. terreus crude extract.

Kinetic analysis of batch ethanol acetylation in isothermal non-stationary multiphase systems by lyophilized mycelium of Aspergillus oryzae

A relatively complex network of reactions has been investigated, using as a network model the isothermal batch esterification of acetic acid with ethanol in n-heptane catalyzed by lyophilized mycelium of Aspergillus oryzae. The kinetic analysis was firstly carried out on the whole system, without any simplification, by means of the well-known integral method. Owing to the poor results obtained by this way, we developed an alternative approach, combining initial rates and integral analysis and reducing the number of empirical parameters to be determined by the use of equilibrium data. All the values of the parameters calculated according to this "composite" approach to kinetic analysis well correlate with experimental data.

Mutagenesis of Aspergillus oryzae IPT-301 to improve the production of ¥â-fructofuranosidase

Aspergillus oryzae IPT-301, previously reported as a ¥â-fructofuranosidase producing microorganism, was successfully mutated using UV irradiation at 253.7 nm followed by the screening of survivors resistant to certain stress conditions. Strains were first subjected to the ¥â-fructofuranosidase activity assay using a portion from the colony grown in Petri dish as the enzyme source. Seven mutants with fructofuranosidase activity values relative to the parent culture between 140 -190 percent were selected from survivors grown at temperature of 40¨¬C or 0.018 percent (w/v) sodium dodecyl sulfate concentration. They were cultivated on a rotary shaker to characterize mycelium and extracellular fructosyltransferase activities. Three mutants named IPT-745, IPT-746 and IPT-748 showed the highest amount of mycelium activity whose values increased 1.5 -1.8 fold, compared with the parent strain. It was found that more than 55 percent of total enzyme activity (mycelium- plus extracellular- activity) from these strains was detected in the mycelium fraction. Only one mutant, IPT-747, exceeded the amount of extracellular enzyme exhibited by the parent strain (1.5 times). This mutant also showed the highest value of total fructosyltransferase activity.

Antibiótico antifungico produzido por um estreptomiceto da região de Araraquara / Antifungal antibiotic produced by a streptomycete isolated in the region of Araraquara (SP), Brazil

Com o aumento significativo na incidência de infecções fúngicas invasivas durante a última década, principalmente em pacientes com câncer, AIDS, ou hospitalizados por período prolongado em unidades de terapia intensiva, há a necessidade da pesquisa de novos agentes antifúngicos com qualidade superior aos existentes. Esta pesquisa objetivou a procura de um microrganismo produtor de substâncias antibacterianas e antifúngicas. Microrganismos das amostras de solo da região de Araraquara, Brasil, foram coletados e analisados quanto ao seu potencial antimicrobiano contra microrganismos padrões (Staphylococcus aureus, Escherichia coli, Candida albicans, Aspergillus oryzae). Das 64 cepas isoladas, 34 apresentaram atividade antimicrobiana. A cepa Ar 4014 foi escolhida para dar continuidade ao trabalho por apresentar boa atividade antimicrobiana contra Candida albicans. Estudos fermentativos mostraram que os Meios 608-K e 602-B foram os melhores para produção e extração de substâncias antifúngicas de Ar 4014. Após cromatografia em coluna de sílica do extrato bruto, as frações ativas obtidas mostraram picos de absorção UV-VIS característicos de pentaenos normais. O antibiótico foi denominado provisoriamente Ara 4014-75